Page 1: Table Of Contents
OUTLINE 1. This manual covers the 64LHP5000 Projector unit. The DTV Decoder is referred to in the DTV Unit Service Manual that will be separately issued.
Page 2: Specifications
64LHP5000 PROJECTOR UNIT Specifications Display and amplifier section Tuner section Screen size ..............64" Circuit type ........Video signal detection: CRT ..........7" High focus CRT x 3 PLL full synchronous detection Brightness (White peak) ......400 Foot-Lambert PLL digital synthesizer system [White window signal input contrast Max.]...
Page 3: Safety Information
64LHP5000 PROJECTOR UNIT SAFETY INFORMATION This service manual is intended for qualified service technicians; it is not meant for the casual do-it- yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair complex products such as those covered by this manual.
Page 4 For continued X-radiation protection, the replacement tube Using a “Leakage Current Tester (Simpson Model 229 must be the same type as the original, SHARP approved equivalent )”, measure for current from all exposed metal type. parts of the cabinet ( input/output terminals, screwheads, The picture tube (the CRT assy R, G, B ) use in this set metal overlays, control shaft, etc.
Page 5 64LHP5000 PROJECTOR UNIT CHARGED SECTION, HIGH VOLTAGE GENERATING POINT AND X-RAY PROTECTION Ë Charged section Ë High voltage generating point The circuit in which the commercial AC power is used as it The place where voltage is 100V is generated.
Page 6: Operation Manual
64LHP5000 PROJECTOR UNIT Front Panel Functions 1 POWER/DOWNLOAD indicator A flip-down door conceals the control panel. Push gently and release, to open the door. To close the door, lift it back Lights when power is on. Flashes when downloading the up into place.
Page 7 V. POSITION: Set to 0. On rare occasions, an electrical discharge may occur inside the CRT. It makes a short, sharp pop and either no sound is produced OPC: or the volume level changes by itself. The TWIN PICTURE and...
Page 8 64LHP5000 PROJECTOR UNIT Remote Control Unit Functions MONITOR (TV) CONTROL BUTTONS 1 POWER button Turns the power of the Rear Projection HDTV on and off. 2 Input button (TV, DTV, INPUT 1 to INPUT 4) Press the button to select the source you wish to watch. The screen will display your selection.
Page 9 64LHP5000 PROJECTOR UNIT w TWIN PICTURE/SEARCH screen buttons TWIN PICTURE: Press to turn the TWIN PICTURE screen function on and off. STROBE: Press to turn the STROBE screen on and off. SEARCH: Press to select the SEARCH screen mode. SELECT: Selects the screen for switching the channel or input source.*...
Page 10 64LHP5000 PROJECTOR UNIT DTV CONTROL BUTTONS 1 AUDIO button Press to select the audio mode during multiaudio broadcasts. 2 Direct channel selection buttons, button Press the buttons that corresponds to the channel that you wish to watch. 3 CH (channel) ', " button Press plus ' or minus "...
Page 11 64LHP5000 PROJECTOR UNIT CABLE CONTROL BUTTONS Cable converters which are made by other makers and are not preset can also be operated using the remote control unit if buttons 1 to 2 have learnt the functions. 1 Direct channel selection buttons Press the button (or buttons) that corresponds to the channel that you wish to watch.
Page 12 64LHP5000 PROJECTOR UNIT VCR CONTROL BUTTONS If the VCR is preset by OPERATION OF REMOTE CONTROL, the remote control unit button will function as follows when the mode switch of the remote control unit is set to VCR. When the input button having the same number as the input terminal connecting the VCR is pressed, the VCR can be operated using buttons 1 to 9.
Page 13: Adjustment
64LHP5000 PROJECTOR UNIT ADJUSTMENT Ë Key Indication of the Remote Control Unit RANGE: OFFSET: SRS ON/OFF CUT-G CONVER GE: TRU ON/OFF CUT-B Cyclically GV (Green, Vertical) RH (Red, Horizontal) GH (Green, Horizontal) RV (Red, Vertical) BV (Blue, Vertical) BH (Blue, Horizontal) •...
Page 14 64LHP5000 PROJECTOR UNIT Ë Jigs and Measuring Instruments · Screwdriver · Adjustment screwdriver Color bar generator D.DC. Volt meter LD player Monoscope Dual trace oscilloscope Frequency counter For HD Signal generator...
Page 15 64LHP5000 PROJECTOR UNIT Ë Assembly Adjustment Location and Items Translucent paper such as tracing paper TUNER • µ-COM ASSY (A SIDE) Lens assy FOCUS VR (VR1) (For Green) Lens assy Lens assy (For Blue) K2702 (For Red) VR2701 FOCUS VR...
Page 16 Vertical size adjustment Horizontal size adjustment If AMP ASSY is repaired or replaced Convergence adjustment Brightness adjustment (SHARP's standard settings) If R, G or B CRT DRIVE ASSY White balance adjustment is repaired or replaced Deflection yoke lean adjustment Screen center adjustment...
Page 17 64LHP5000 PROJECTOR UNIT Ë Factory ADJ Mode Start ....Start adjusting 1st FAC .... Select 1st factory adjustment mode, then adjust. Select 1st FACTORY ADJ Mode Selecting the mode for adjustment operations. Start Front panel Normal picture The 2nd factory adjustment Cyclically “ON”...
Page 18 64LHP5000 PROJECTOR UNIT Adjustment Range Mode Picture quality, eyc., Change amount check made operating. 1st FAC Start ADJUSTMENT PD5462A RANGE : COLOR, BASS : TINT, COLOR, BASS TREBLE Telop : Red : CONTRAST, BALANCE : BRIGHT <VOLUME> : SHARP- NESS...
Page 19 64LHP5000 PROJECTOR UNIT Size Mode 1st FAC Start • Mode for roughly adjusting the horizontal and vertical sizes of the main deflection. • In this mode, the color is green only, screen size is FULL and the contrast is +10.
Page 20 64LHP5000 PROJECTOR UNIT Convergence Setting Mode 1st FAC Start Screen mode ADJUSTMENT FULL –128~127 –120 GV STATIC Adjustment item Data value Variety Telop : White <Variety section> <Data value section> Cyclically GV (Green, vertical) RH (Red, horizontal) ADJUSTMENT FULL GH (Green, horizontal)
Page 21 64LHP5000 PROJECTOR UNIT Panel Adjustment Mode 1st FAC Start • Mode for adjusting the brightness, width, and position of the gray part (panel) of the 4:3 normal screen. <Data value section> ADJUSTMENT PANEL BRIGHT –24 Telop : Yellow Data value <Adjustment item section>...
Page 22 64LHP5000 PROJECTOR UNIT Adjustment MPX Mode For adjusting the TV tuner MPX decoder section Auto adjust 1st FAC Start ADJUSTMENT MPX F.E 1 ADJUSTMENT MPX F.E 1 1 ATT 5 SAP LPF 1 ATT 5 SAP LPF 2 ST VCO...
Page 23 64LHP5000 PROJECTOR UNIT Ë Adjustment Power supply adjustment -1 135V Power supply adjustment Color-bar generator Start D. DC voltmeter Color bar TP201 VR201 135.0V±1V POWER SUPPLY VR201 ASSY -2 14.5V Power supply adjustment Start Color-bar generator D. DC voltmeter Color bar...
Page 24 64LHP5000 PROJECTOR UNIT Brightness adjustment 1st FAC Start ADJUSTMENT OFFSET CUTR Data value Telop : Blue BRIGHT CUT-R Oscilloscope TP-GK G CRT DRIVE assy CUT-B Cut of level (180V DC) Deflection yoke lean adjustment Start Deflection Deflection CRT assy G...
Page 25 64LHP5000 PROJECTOR UNIT Screen center adjustment Start • For Red or Blue adjustment, turn 1st FACTORY ADJ mode ON and then OFF to place the convergence POSITION at the center of the adjustable range. • Move the centering magnet of the deflection yoke for the...
Page 26 64LHP5000 PROJECTOR UNIT Vertical size adjustment Note : After the V. SIZE adjustment, enter the H. SIZE adjustment by 1st FAC Start pressing “1” key and readjust. Screen mode : FULL 91% ± 2% Monoscope Green screen V.SIZE General Adjust the size so that the picture is completely broadcasting displayed on the screen.
Page 27 64LHP5000 PROJECTOR UNIT Horizontal size adjustment Note : 1st FAC Start Screen mode : FULL Monoscope Green screen 91% ± 2% H.SIZE General Adjust the size so that the picture is completely broadcasting displayed on the screen.
Page 28 64LHP5000 PROJECTOR UNIT Convergence adjustment -1 Green line adjustment 1st FAC Note : • Adjustment in the horizontal direction The convergence for this device must be adjusted for each Start screen size FULL (NTSC, 4:3 NORMAL), ZOOM (NTSC), CIN- EMA WIDE (NTSC), NATURAL WIDE (NTSC), FULL (HD) »...
Page 29 64LHP5000 PROJECTOR UNIT » Horizontal correction adjustment of the green line • Select the Adjustment item GH - SUB PIN • Adjust the Data value Note : • Repeat the adjustments until you attain the optimum state. • Fine-adjust over the entire picture to obtain the optimum picture.
Page 30 64LHP5000 PROJECTOR UNIT -2 Green line adjustment 1st FAC • Adjustment in the vertical direction Start » Vertical correction adjustment of the green line • Select the Adjustment item GV - STATIC • Adjust the Data value Note : • Repeat the adjustments until you attain the optimum state.
Page 31 64LHP5000 PROJECTOR UNIT » Vertical correction adjustment of the green line • Select the Adjustment item GV - SUB PIN • Adjust the Data value Note : • Repeat the adjustments until you attain the optimum state. • Fine-adjust over the entire picture to obtain the optimum picture.
Page 32 64LHP5000 PROJECTOR UNIT -3 Red line adjustment 1st FAC • Adjustment in the horizontal direction Start » Horizontal correction adjustment of the red line • See Convergence Setting Mode in the Factory ADJ mode. • Input cross-hatch signals to this device’s video input terminal.
Page 33 64LHP5000 PROJECTOR UNIT » Horizontal correction adjustment of the red line • Select the Adjustment item RH - SUB PIN • Adjust the Data value Note : • Repeat the adjustments until you attain the optimum state. • Fine-adjust over the entire picture to obtain the optimum picture.
Page 34 64LHP5000 PROJECTOR UNIT -4 Red line adjustment 1st FAC • Adjustment in the vertical direction Start » Vertical correction adjustment of the red line • Select the Adjustment item RV - STATIC • Adjust the Data value Note : • Repeat the adjustments until you attain the optimum state.
Page 35 64LHP5000 PROJECTOR UNIT » Vertical correction adjustment of the red line • Select the Adjustment item RV - SUB PIN • Adjust the Data value Note : • Repeat the adjustments until you attain the optimum state. • Fine-adjust over the entire picture to obtain the optimum picture.
Page 36 64LHP5000 PROJECTOR UNIT -5 Blue line adjustment 1st FAC • Adjustment in the horizontal direction Start » Horizontal correction adjustment of the blue line • See Convergence Setting Mode in the Factory ADJ mode. • Input cross-hatch signals to this device’s video input terminal.
Page 37 64LHP5000 PROJECTOR UNIT » Horizontal correction and adjustment of blue line • Select the Adjustment item BH - SUB PIN • Adjust the Data value Note : • Repeat the adjustments until you attain the optimum state. • Fine-adjust over the entire picture to obtain the optimum picture.
Page 38 64LHP5000 PROJECTOR UNIT -6 Blue line adjustment 1st FAC • Adjustment in the vertical direction Start » Vertical correction adjustment of the blue line • Select the Adjustment item BV - STATIC • Adjust the Data value Note : • Repeat the adjustments until you attain the optimum state.
Page 39 64LHP5000 PROJECTOR UNIT » Vertical correction adjustment of the blue line • Select the Adjustment item BV - SUB PIN • Adjust the Data value Note : • Repeat the adjustments until you attain the optimum state. • Fine-adjust over the entire picture to obtain the optimum picture.
Page 40 64LHP5000 PROJECTOR UNIT Test cross H-center position adjustment Start (LD player) : ADJ CONVERGE TUNER µ-COM ASSY Adjust the position so that the L2202 test cross is placed at the center of the screen. L2202 TV SET UP CONVERGENCE SAT CONTROL...
Page 41 64LHP5000 PROJECTOR UNIT -2 Video level adjustment 2 Start Double screen (P IN P) not 75Ω terminal P IN P ANT.A ON/OFF INPUT SHIFT J2703 4 pin EXIT 1Vp-p ± 0.10V VR2801 TUNER µ-COM VR2801 ASSY -3 Stereo VCO adjustment...
Page 42 64LHP5000 PROJECTOR UNIT -4 SAP VCO adjustment 1st FAC Start 1. ATT 5. SAP UF 2. ST VCO 6. WIDE BAN 12 3. SAP VC 7. SPECTRA 4. STUF Oscillator TUNER µ-COM ASSY 00001 “COMPLETE” 1. ATT 5. SAP UF 2.
Page 43 64LHP5000 PROJECTOR UNIT -5 STEREO LPF adjustment 1st FAC ADJUSTMENT MPX Start Oscillator 1. ATT 5. SAP LPF 2. ST VCO 6. WIDE BAN TUNER µ-COM ASSY 3. SAP VC 7. SPECTRA 4. ST LPF 00000 “COMPLETE” K2702 Q2708 (TP-MPX) 9.4kHz...
Page 44 64LHP5000 PROJECTOR UNIT -7 Separation adjustment (WIDE BAND) 1st FAC Start Adjust the output of the TV OUT terminal on the rear panel to the minimum level. R ch level - L ch input (RF) minimum 1. ATT 5. SAP UF 2.
Page 45 (Don't signal move the screen VR and CUT-G). : CUT-R : CUT-B SHARP’s standard settings -1 Sharpness adjustment 1st FAC Start STD OFFSET Telop : Blue Oscilloscope “Multiburst”...
Page 46 64LHP5000 PROJECTOR UNIT -3 Tint adjustment 1st FAC Start “Color bar” ADJUSTMENT OFFSET TINT Adjust the screen to optimum condition. -4 Contrast adjustment Start 1st FAC “Color bar” Adjust the screen to optimum condition. “Normal video signal” At the TP-BK of the B. CRT DRIVE assy, check that the...
Page 47 64LHP5000 PROJECTOR UNIT Side panel adjustment (Screen size 4 : 3) -1 Panel position adjustment 1st FAC Start (ADJUSTMENT PANEL MODE) “Monoscope” <Panel position data value> ADJUSTMENT PANEL POSITION –24 Telop : Yellow Data value “Monoscope” <Panel width data value>...
Page 48 64LHP5000 PROJECTOR UNIT -2 Adjustment of panel luminance 1st FAC Start (ADJUSTMENT PANEL MODE) <Panel bright> <Data value > “Monoscope” ADJUSTMENT PANEL BRIGHT –24 Telop : Yellow Data value Screen mode 4 : 3 Adjust the TP-G.K panel level to 160V.
Page 49 64LHP5000 PROJECTOR UNIT SPLIT screen adjustment 1st FAC Start (SIGNAL ADJUSTMENT MODE) Double screen ADJUSTMENT SUGNAL COMPOSITE –24 MAIN CONTRAST Data value -1 Luminance adjustment (SUB CONTRAST) Double screen • Adjust the left and right screens to the same “WHITE”...
Page 50: General Information
64LHP5000 PROJECTOR UNIT GENERAL INFORMATION Ë WIRING DIAGRAM Reconnect any disconnected lead wires of the Projection monitor receiver. The important points for connection of the lead wires are as shown below. You may find that they were connected differently. Be sure reconnect the lead wires as they were.
Page 51 64LHP5000 PROJECTOR UNIT Ë IC » The information shown in the list is basic information and may not correspond exactly to that shown in the schematic diagrams. » List of IC TA8638N CA0007AD CXA1315P STK4412 NJM2187L PD5462A9 PD5463B9 PD5497B9 PD0264AM...
Page 52 64LHP5000 PROJECTOR UNIT » Pin Function Pin No. Pin Name Function Pin for preventing radiation of X-ray from CRT. X-ray protection input When this pin is set above 1.3V (standard), the horizontal output will stop until H.VCC becomes a low level.
Page 53: Pin Assignment
64LHP5000 PROJECTOR UNIT Pin No. Pin Name Function Horizontal sync separation output pin. Sync separation output Separates and outputs the sync signal of the composite signal input to Pin 24. Sync separation input Horizontal sync separation input pin. Ë CA0007AD (AMP ASSY: IC907) DUAL ANALOG MULTIPLIER IC »...
Page 54 64LHP5000 PROJECTOR UNIT » Pin Function Pin No. Pin Name Function Input/output pin of the general I/O port. VILmax: 1.5V VIHmin: 3V VOLmax: 0.4V DAC4 DAC3 DAC2 D/A converter output pin. DAC1 DAC0 — GND pin. Input/output pin of the general I/O port.
Page 55 64LHP5000 PROJECTOR UNIT Ë NJM2187L (AMP ASSY: IC1204) SURROUND IC » Pin Assignment F_OUT MODE2 F_IN MODE1 VREF CE_IN2 FI_IN Rch IN Lch IN FIL1_OUT FIL1_IN Rch OUT SPACE_OUT Lch OUT FIL2_IN2 SPACE_IN FIL2_IN CENTER_OUT FIL2_OUT CENTER_IN » Pin Function Pin No.
Page 56 Analog DC voltage input for determination of KEY input – DPO analog voltage input – YOBI Unused – SRDY SRDY signal for communication with sharp microprocessor MCLK MCLK signal for communication with sharp microprocessor – MDATA MDATA signal for communication with sharp microprocessor – SDATA SDATA signal for communication with sharp microprocessor –...
Page 57 64LHP5000 PROJECTOR UNIT Pin No. Pin Name Function C.MUTE Converter mute output. When AC is supplied:L, Discharge:H. MUTE ON: L, OFF: H C.ENB ENB output for PM0011 AS (convergence DAC IC) control. Communication permission: L PM0011AS (convergence DAC IC, IC1403, IC1408-IC1412), HG62G010R29FB (auto zoom IC, IC4005) –...
Page 58 64LHP5000 PROJECTOR UNIT Ë PD5463B9 (TUNER µ-COM: IC2202) SUB µ-COM » Pin Function Pin No. Pin Name Function DH BLK CCD display sync signal double speed HBLK input Positive polarity V BLK2 CCD display sync signal VBLK input Positive polarity...
Page 59 64LHP5000 PROJECTOR UNIT Pin No. Pin Name Function Switches between external double speed component input signal, External double speed: H AUX SW DTV 1080 signal, and double speed component signal double Others: L speed signal processed inside the unit COMP3 MUTE...
Page 60 64LHP5000 PROJECTOR UNIT Pin No. Pin Name Function – Supplies 0V – – Supplies +5V power supply – OSC1 Clock input for display – OSC2 Clock output for display – RESET RESET input RESET:L Unused – Unused – Unused –...
Page 61 64LHP5000 PROJECTOR UNIT Ë PD0264AM (TUNER µ-COM ASSY: IC2206) OSD (On-Screen Display) IC » Pin Assignment » Block Diagram AVSS 28 AVSS2 AVDD 27 R Clock Dot clock generator OSCIN 26 G OSCOUT AVSS OSCIN 25 B Text RAM Display...
Page 62 64LHP5000 PROJECTOR UNIT » Pin Function Pin No. Pin Name Function AVSS — Ground pin of the analog circuit section. An external low-pass filter is connected. The free-running frequency of VCO is determined. OSCIN Oscillation input pin. This pin must be secured to the ground level.
Page 63 64LHP5000 PROJECTOR UNIT Ë TA1276AN (VIDEO ASSY: IC5251) CHROMA SYNC DEFLECTION PROCESSING IC PAL/NTSC SYSTEM COLOR TV IC » Block Diagram fsc Output SENS Input Output Cut-Off Cut-Off R S/H High Bright SCP Output R S/H Output Color SECAM Color...
Page 64 64LHP5000 PROJECTOR UNIT » Pin Function Pin No. Pin Name Function I/O Signal Outputs the VCXO oscillation waveform. 3.58 NTSC colored:3.2V Inputs the 3.58 NTSC signal, and the output DC becomes 3.2V fsc output Black/white/Other system:1.4V only for color. It is 1.4V for Black/white and other signals.
Page 65 64LHP5000 PROJECTOR UNIT Pin No. Pin Name Function I/O Signal (1) When bus HD-OUT=0, outputs the HD pulse imposed with 1µs AFC (pulse width:1 us). Ext BPP HD output Also provided with a BPP (black peak detection stop pulse) signal external input function.
Page 66 64LHP5000 PROJECTOR UNIT Pin No. Pin Name Function I/O Signal B S/H S/H (sample hold) pin for AKB mode or clamp mode. G S/H S/H (sample hold) pin for AKB mode or clamp mode. VP output Vertical pulse output. Switch for switching the internal RGB signal and analog RGB A.
Page 67 64LHP5000 PROJECTOR UNIT Pin No. Pin Name Function I/O Signal Soft AKB 7.0V YM input Internal RGB signal halftone SW. Halftone 0.75V Outputs the DC played back Y signal which had passed through VSM output HPF. 3.5V The output is muted by the pins 32 and 36 switches.
Page 68 64LHP5000 PROJECTOR UNIT Ë AN5344FBP (SUB VIDEO ASSY: IC4201) COLOR CONTROL IC » Block Diagram CENT +C.C –C.C C.S.C C.G.C GND 4 GND 3 I.G.C CONT K.G.C Clamp H B-Y OUT VCC 4 CNR R-Y IN VCC 3 Polarity Color compensation...
Page 69 64LHP5000 PROJECTOR UNIT Pin No. Pin Name Function Pin No. Pin Name Function C.G.C Color compensation gain control CNR R-Y IN CNR R-Y input C.S.C Color compensation stop control CNR B-Y IN CNR B-Y input – C.C – side compensation control...
Page 70 64LHP5000 PROJECTOR UNIT » Pin Function Pin No. Function Pin No. Function input Sharpness mute control VM preamplifier gain control Sharpness control VM preamplifier input Y output VM preamplifier output Contour gain control Sub screen Ys input Contour bias Secondary differential input...
Page 71 64LHP5000 PROJECTOR UNIT Ë SAA7165WP (SUB VIDEO ASSY: IC4702) VIDEO ENHANCEMENT D/A » Pin Assignment » Block Diagram CUR V DDD1 DDD2 DDA1 DDA2 DDA3 DDA4 Y7 to Y0 21 to 14 PEAKING 25Ω DAC 3 FORMATTER CORING REFL SSA3...
Page 72 64LHP5000 PROJECTOR UNIT Pin No. Pin Name Function C-bus clock line c-bus data line VSS D2 Digital ground 2(0V) — VDD D2 — +5V digital supply voltage 2 VDD A1 — +5V analog supply voltage for buffer of DAC 1 (R-Y) ±...
Page 73 64LHP5000 PROJECTOR UNIT » Pin Function Function Pin No. Pin Name Not connected — Decoupling input (internal stabilization loop decoupling) REG1 Y analog voltage input Decoupling input (internal stabilization loop decoupling) REG2 Y clamp capacitor connection CLPY Analog positive supply voltage (+5V) VCC A —...
Page 74 64LHP5000 PROJECTOR UNIT Ë SAA4952WP (SUB VIDEO ASSY: IC4704) MEMORY CONTROLLER » Pin Assignment » Block Diagram SAA4952WP MICROCONTROLLER INTERFACE PROCESSING STROBE SWC1 VACQ SWC05 VDFL ACQUISITION HRA/BLNA HWE1 STROBE HORIZONTAL HDFL (12,13.5,16,18MHz) TIMING VACQS HRA/BLNA HRDFL TEST SAA4952WP LOGIC...
Page 75 64LHP5000 PROJECTOR UNIT » Pin Function Pin No. Pin Name Function Read enable signal output (memory 2) BLND Horizontal branking signal output (display part) Address latch enable signal input Wrirw/read data signal input VCC 2 Supply voltage 3 — VSS 2 Ground 2 —...
Page 76 64LHP5000 PROJECTOR UNIT Ë TMS4C2973-26 (SUB VIDEO ASSY: IC4705, IC4706) 2.9M FIELD MEMORY » Pin Assignment SSOP SWCK SRCK RSTW RSTR » Pin Function Pin No. Pin Name Function Pin No. Pin Name Function Vss1 — Ground Vcc2 — 3.3V power supply voltage...
Page 77 64LHP5000 PROJECTOR UNIT Ë CD74HCT4046AM (SUB VIDEO ASSY: IC4713) PLL IC » Pin Assignment » Block Diagram VCO OUT COMP IN SIG IN PHASE COMP OUT I PHASE I CURRENT AMP. PHASE III COMP CURRENT MIRROR "1" PHASE II CURRENT "1"...
Page 78 64LHP5000 PROJECTOR UNIT Ë SAA4990H (SUB VIDEO ASSY: IC4719) PROZONIC IC » Pin Assignment » Block Diagram TEST1/AP REFPRMATTER TEST2/SP LINE LINE NOISE LINE MEMORY 2 MEMORY 3 FORMATTER REDUCTION MEMORY 1 SNCL MIXER MIXER REFPRMATTER SNDA SNRST LINE LINE...
Page 79 64LHP5000 PROJECTOR UNIT » Pin Function Pin No. Pin Name Function YUV B8 UV bit 0 from FM2 YUV B9 UV bit 1 from FM2 YUV B10 UV bit 2 from FM2 YUV B11 UV bit 3 from FM2 YUV B0...
Page 80 64LHP5000 PROJECTOR UNIT Pin No. Pin Name Function YUV A4 Y bit 4 from FM1 YUV A3 Y bit 3 from FM1 YUV A2 Y bit 2 from FM1 VSS 8 Ground 8 — VDD 8 Supply voltage 8 —...
Page 81 64LHP5000 PROJECTOR UNIT Ë PQ05RD1B (SIGNAL ASSY: IC7007, IC7105) REGULATOR » Pin Assignment » Block Diagram Exclusive IC » Pin Function Pin No. Function DC input (Vin) DC output (Vo) – ON/OFF control (Vc) Ë UPD64081BGF-3BA (SIGNAL ASSY: IC7002) 3D Y/C SEPARATION IC »...
Page 82 64LHP5000 PROJECTOR UNIT » Pin Function Pin No. Pin Name Function DGND Digital block ground – Address output for external EDO memory MCAS CAS output for external EDO memory (Active low) WE output for external EDO memory (Active low) OE output for external EDO memory (Active low)
Page 83 64LHP5000 PROJECTOR UNIT Pin No. Pin Name Function AVDD fsc generator DAC block power supply – FSCO fsc generator fsc output – AGND fsc generator DAC block ground – AGND 8fsc-PLL ground – FSCI 8fsc-PLL fsc input – CPLL 8fsc-PLL filter output (Opened or connected to GND) –...
Page 84 64LHP5000 PROJECTOR UNIT Pin No. Pin Name Function DGND Digital block ground – AVDD Y-DAC, C-DAC power supply – CBPC C-DAC phase compensation output C-DAC analog C signal output Y-DAC analog Y signal output CBPY Y-DAC phase compensation output AGND Y-ADC, C-DAC ground –...
Page 85 64LHP5000 PROJECTOR UNIT » Pin Function Pin No. Pin Name Function I/O Signal Connected to X'tal. Oscillation frequency f0 and frequency 4.43 MHz X'tal adjustment range can be changed in series capacity and parallel DC 4.0V N-X'tal capacity respectively. 90 mVp-p Frequency adjustment range for oscillation frequency f0 with 3.58 MHz X'tal...
Page 86 64LHP5000 PROJECTOR UNIT Pin No. Pin Name Function I/O Signal 8.3V Outputs the SCP (Sand Castle Pulse). 4.8V SCP output The output signals are clamp pulse, horizontal blanking pulse, and 2.5V vertical blanking. Dig GND — Logic block GND pin.
Page 87 64LHP5000 PROJECTOR UNIT Pin No. Pin Name Function I/O Signal 1Vp-p Y input Input pin for composite video signal or Y signal. 2.5V DAC Vcc — VCC pin for DAC block and chroma processing block. – C Vcc — Connected to 5V (standard).
Page 88 64LHP5000 PROJECTOR UNIT Ë PQ09RD1B (SIGNAL ASSY: IC7106) REGULATOR » Pin Assignment » Block Diagram Exclusive IC » Pin Function Pin No. Function DC input (Vin) DC output (Vo) – ON/OFF control (Vc) Ë CXA2119M (SIGNAL ASSY: IC7250) (For SIGNAL ASSY AWV1725) Y COLOR DIFFERENCE I/F SW »...
Page 89 64LHP5000 PROJECTOR UNIT » Pin Function Pin No. Pin Name Function Y1 IN Pin for inputting the YCbCr signal. Cb1 IN Inputs the YCbCr specifications (0.7 Vp-p for 100% color bar) signal. Cr1 IN The pedestal level of the input signal is clamped at 4V.
Page 90 64LHP5000 PROJECTOR UNIT Pin No. Pin Name Function Control pin for the output selection SW of the 3 input composite video signals. SEL1 SEL2 SIG OUT SIG1 SEL2 High SIG2 High SIG3 High High Prohibited VILMAX=0.5V, VIHMIN=3.5V Pin for inputting the composite video signal.
Page 91 64LHP5000 PROJECTOR UNIT » Pin Function Pin No. Pin Name Function AVSS Analog GND – Reference pin for ADC. – Reference pin for ADC. – ADIN Composite video signal input pin. BIAS1 Bias pin for ADC. – TEST TEST pin. Connected to the digital GND.
Page 92 64LHP5000 PROJECTOR UNIT » Pin Function Function Pin No. Pin Name Analog power supply pin (+5 V) – Analog power supply pin (+5 V) – Analog power ground pin (0 V) – Digital output pins. D : MSB, D : LSB Digital power ground pin (0 V) —...
Page 93 64LHP5000 PROJECTOR UNIT » Pin Function Pin No. Pin Name Function – Y7MI Y6MI Y5MI Y4MI Main screen Y signal input Y3MI Y2MI Y1MI Y0MI CB7MI CB6MI CB5MI CB4MI Main screen Cb signal input CB3MI CB2MI CB1MI CB0MI CR7MI CR6MI...
Page 94 64LHP5000 PROJECTOR UNIT Pin No. Pin Name Function – – Y1SI Y signal input/R signal input for sub screen (When inputting VGA) Y0SI CB7SI CB6SI CB5SI CB4SI Cb signal input/G signal input for sub screen (When inputting VGA) CB3SI CB2SI...
Page 95 64LHP5000 PROJECTOR UNIT Pin No. Pin Name Function – – Display screen digital G signal output WCKO External D/A -C clock output for RGB output – Display screen digital B signal output TMC1I Test input (Normally LOW input) TBUSD Tbus DATA signal input/output...
Page 96 64LHP5000 PROJECTOR UNIT Pin No. Pin Name Function – – CASB1O LCAS, UCAS to DRAM 1 for multi window – CASB2O LCAS, UCAS to DRAM 2 for multi window – RASB1O RAS to DRAM 1 for multi window – –...
Page 97 64LHP5000 PROJECTOR UNIT Ë HY514264BJC-50A (SIGNAL ASSY: IC7003, IC7701, IC7702) 4M DRAM » Pin Assignment » Block Diagram DQ14 DQ15 40 Vss 39 DQ15 38 DQ14 DATA INPUT DATA INPUT 37 DQ13 20 OE BUFFER BUFFER DQ0-7 DQ8-15 DQ0-7 DQ8-15...
Page 98 64LHP5000 PROJECTOR UNIT Ë TLC2932IPW (SIGNAL ASSY: IC7703, IC7704) PLL IC » Pin Assignment » Block Diagram VCO V LOGIC V SELECT BIAS VCO OUT COIN VCO GND 1/2 DIVIDER VCO INHIBIT PFD INHIBIT PFD OUT LOGIC GND » Pin Function Pin No.
Page 99 64LHP5000 PROJECTOR UNIT Ë PD5499A (SIGNAL ASSY: IC7800) CONTROL µ-COM » Pin Assignment » Pin Function Pin No. Pin Name Function Unused Unused Unused Unused MREQ M-S serial main request input Unused T bus period output T bus clock output...
Page 100 64LHP5000 PROJECTOR UNIT Pin No. Pin Name Function RESET Reset input System clock input XOUT System clock output Power supply input (GND) TVGP+ vertical sync signal output PASS 1-screen through switching output S_SW Sub composite /S switching output M_SW Main video/EPG switching output...
Page 101 64LHP5000 PROJECTOR UNIT Ë 24LC08B(I)SN (SIGNAL ASSY: IC7802) 8K EEPROM » Pin Assignment » Block Diagram HV GENERATOR EEPROM MEMORY ARRAY CONTROL CONTROL XDEC LOGIC LOGIC PAGE LATCHES YDEC SENSE AMP R/W CONTROL » Pin Function Pin No. Pin Name...
Page 102: Block Diagrams
64LHP5000 PROJECTOR UNIT BLOCK DIAGRAMS Ë µ-COM BLOCK SIGNAL ASSY IC7801 IC7800 IC7802 IC2205 IC2203 IC2207 IC2201 IC220 IC2206 IC2204 IC2209 IC1171 AMP ASSY CONVER DAC ASSY...
Page 103 64LHP5000 PROJECTOR UNIT SUB VIDEO ASSY OSC SW2 C2203 IC4405 IC2202 IC5254 VIDEO ASSY...
Page 104 64LHP5000 PROJECTOR UNIT Ë AUDIO BLOCK IC2702 IC2701 IC6402 IC6001 IC6401...
Page 105 64LHP5000 PROJECTOR UNIT IC1204 IC1205 – 6.5dB 12, 11 IC1201 IC1201 IC1201 IC1207 + 23.5dB IC1202 - 3 .5...
Page 106 64LHP5000 PROJECTOR UNIT Ë VIDEO BLOCK (OTHERS MODEL) (SIGNAL ASSY) (OTHERS MODEL) IC7305 IC7703, IC6003 IC7704 IC4002 IC7300 IC7250 IC7702, (OTHER MODEL) IC7003 IC7701 IC7002 IC7710 IC7700 IC6001 IC4006 IC4 IC7103 IC7100 IC7305 IC7800 IC7307 IC6403 IC7306 IC7801 (AV I/O ASSY) (TUNER µ-COM ASSY)
Page 107 64LHP5000 PROJECTOR UNIT (SUB VIDEO ASSY) IC4703 IC4705 IC4702 IC3801 IC4402 IC4404 IC4719 IC4005 IC4706 IC4002 IC4704 IC4720 IC4004 IC4007 IC4001 IC4006 IC4003 IC4718 IC4004 IC4405 OSC SW1 IC4403 IC5101 (R), (VIDEO IC5151 (G), ASSY) IC5201 (B) IC5251 IC5253 IC5254...
Page 108: Schematic Diagram
64LHP5000 PROJECTOR UNIT Ë OVERALL CONNECTION DIAGRAM SCHEMATIC DIAGRAM CONNECTOR ASSY AMP ASSY (AWV1712) (AWZ6335) CONVER.DAC ASSY (AWZ6333) SIGNAL ASSY (AWV1725) TUNER µ-COM ASSY (AWV1723) VIDEO ASSY (AWV1724) LED DPO ASSY (AWZ6348) FRONT CONTROL ASSY (AWZ6337) SR BNC ASSY (AWZ6351)
Page 109 64LHP5000 PROJECTOR UNIT B CRT DRIVE ASSY (AWZ6346) ASSY G CRT DRIVE ASSY (AWZ6345) AWZ6333) R CRT DRIVE ASSY (AWZ6344) ASSY (AWV1725) DEFLECTION SUB VIDEO ASSY (AWV1726) SERVICE ASSY (AWV1731) POWER SUPPLY ASSY (AWV1710) AC IN ASSY (AWZ6354) 10A 250V...
Page 110 64LHP5000 PROJECTOR UNIT Ë TUNER µ-COM ASSY (1/3) TUNER µ-COM ASSY (1/3) (AWV1723) • TUNER 1 BLOCK IC2701 (CXA1734 Voltage – – Not used 1.25 1.25...
Page 111 64LHP5000 PROJECTOR UNIT FRONT END 701 (CXA1734S) M2701 (M2801) Voltage Voltage Voltage Voltage – – – – – – – – – *M2801 [5V] SIGNAL ROUTE : Video Signal Route (TV1,TV2) : Audio Signal Route (TV1.L,TV2.L) : Composite Audio Signal Route –...
Page 112 64LHP5000 PROJECTOR UNIT Ë TUNER µ-COM ASSY (2/3) TUNER µ-COM ASSY(2/3) (AWV1723) • TUNER 2 BLOCK 1.25 4. 7 1.25 (TV2) (TV2)
Page 113 64LHP5000 PROJECTOR UNIT (TV2) SIGNAL ROUTE (TV2) : Video Signal Route (TV2) : Composite Audio Signal Route...
Page 114 64LHP5000 PROJECTOR UNIT Ë TUNER µ-COM ASSY (3/3) TUNER µ-COM ASSY (3/3) (AWV1725) • µ-COM BLOCK J5024 V2 1.25 R2233 CN5001 DTV SET TOP BOX SH-DO7 8. 1 CN209 E2 IC2207: RESET 5V(1) 9V(1) 1/3,2/3 TV_GND +13.5V(2) SCL5 SAA5 AFT1...
Page 115 64LHP5000 PROJECTOR UNIT Guide page Large size SCH diagram Detailed page CN5605 D2334 D2336 R2233 C2216 100/10 8. 1 IC2205: RESET 1. 25 2/2 CN5604 C2225 0.01 D2207 R2573 Q2227 Q2228 R2536 R2564 R2566 3.3K Q2229 Q2226 R2568 R2562 R2335 4.
Page 116 TUNER µ-COM ASSY (3/3) (AWV1725) • µ-COM BLOCK J5024 V2 1.25 R2233 CN5001 DTV SET TOP BOX SH-DO7 CN209 E2 IC2207: RESET 5V(1) 9V(1) 1/3,2/3 TV_GND +13.5V(2) SCL5 SAA5 AFT1 AFT2 H_SYNC1 H_SYNC2 MTS_SW1 ANT_SW1 ANT_SW2 SCL1 SDA1 SUB_V TV_V CN210...
Page 117 TV_V CN210 CN1205 CN908 0. 1 4. 3 R2412 R2446 CN308 0. 7 0. 7 0. 7 13. 5 2. 8 0. 7 2. 8 9. 8 2. 8 10. 4 C2264 1.0/50...
Page 118 64LHP5000 PROJECTOR UNIT...
Page 119 D2207 R2573 Q2227 Q2228 R2536 R2564 R2566 3.3K Q2229 Q2226 R2568 R2562 R2335 4. 3 0. 2 4. 7 4. 7 0. 2 SIGNAL ROUTE : Video Signal Route 0. 7 0. 6 2. 8 1. 7 Note: As for voltages of IC2201, IC2202 and IC2203 refer to page 196.
Page 120 64LHP5000 PROJECTOR UNIT Ë VIDEO ASSY (1/2) IC5253, Q5291-Q5299: Circuit switching between IC5255, Q5313-Q5317: PANEL signal generation circuit for screen size 4:3 CCD signal and PANEL signal Q5288-Q5290, Q5318-Q5320: Black extension circuit (Black level compensation) Q5307-Q5312: V BLK width extension for HD...
Page 121 64LHP5000 PROJECTOR UNIT Q5299: between Q5251-Q5253, Q5282-Q5284: NEL signal OSD buffer VIDEO ASSY (1/2) (AWV1724) • VIDEO BLOCK IC5252, Q5301:PANEL BLK generation circuit for screen size 4:3 CN5101 CN5151 CN5201 Y color R.G.B. Conversion block difference CN904 BL & ACL block...
Page 122 64LHP5000 PROJECTOR UNIT Ë VIDEO ASSY (2/2) 8/9 CN7800 X3 CN6404 A8 CN2202 T7 CN6201 CN2208 T8 CN7600...
Page 123 64LHP5000 PROJECTOR UNIT VIDEO ASSY (2/2)(AWV1724) CN3801 Y2 • CN SW BLOCK IC5605, Q5602-Q5608, Q5610, Q5611:SYNC MASK circuit (Change the pedestal level for black extension) CN3802 Y3 IC5601-IC5604, Q5601: REGULATOR...
Page 124 64LHP5000 PROJECTOR UNIT Ë SUB VIDEO ASSY (1/5) SUB VIDEO ASSY(1/5) (AWV1726) • ASPECT BLOCK IC4002: VIDEO A/D CONVERTER IN PUT CLAMP IC4003: VIDEO A/D CONVERTE IC4007:ASPECT SW...
Page 125 64LHP5000 PROJECTOR UNIT IC4004: AFC PLL AUTO ZOOM IC4003: VIDEO A/D CONVERTER ASPECT CONVERSION...
Page 126 64LHP5000 PROJECTOR UNIT Ë SUB VIDEO ASSY (2/5) SUB VIDEO ASSY(2/5) (AWV1726) • PROGRESSIVE BLOCK...
Page 127 64LHP5000 PROJECTOR UNIT IC4713:PLL IC4702 IC4704 Vol.(V) Vol.(V) Vol.(V) Vol.(V) Vol.(V) Vol.(V) Vol.(V) Vol.(V) Vol.(V) Vol.(V) — — — — — — — — — — — — — — — — — — — — — — — —...
Page 128 64LHP5000 PROJECTOR UNIT Ë SUB VIDEO ASSY (3/5) SUB VIDEO ASSY(3/5) (AWV1726) • EQ BLOCK EQ BLOCK H. BLOCK, CLAMP PULSE generation circuit...
Page 129 64LHP5000 PROJECTOR UNIT COLOR CONTROL...
Page 130 64LHP5000 PROJECTOR UNIT Ë SUB VIDEO ASSY (4/5) SHARPNESS CONTROL (For HD) IC4402: F_SW SHARPNESS (For NTSC)
Page 131 64LHP5000 PROJECTOR UNIT SUB VIDEO ASSY(4/5) (AWV1726) • SHARPNESS BLOCK IC4404: Switching of sharpness IC4405: DAC(DC CONTROL) F_SW...
Page 132 64LHP5000 PROJECTOR UNIT Ë SUB VIDEO ASSY (5/5) Switching of internal/external double speed signals* *NTSC: 31.5 kHz, DTV: 33.75 kHz Not used Not used Switching of sync signals of internal/external double speed signals Sync separation of external double speed input signal...
Page 133 64LHP5000 PROJECTOR UNIT SUB VIDEO ASSY(5/5) (AWV1726) • SYNC SEPA BLOCK used used gnals 1/5,3/5 1/5,4/5 CN5606 U5 CN305 K6...
Page 134 64LHP5000 PROJECTOR UNIT Ë SIGNAL ASSY (1/9) SIGNAL ASSY(1/9) (AWV1725) IC7004: 8bit A/D Conv • 3D Y/C SEP BLOCK 3. 3 3. 3 3. 3 3. 3 1.8 1.8 1.8 1.8 1.8 1.8 1.8 1.8 1.8 CN6003...
Page 135 64LHP5000 PROJECTOR UNIT IC7004: 8bit A/D Converter 4. 3 SIGNAL ROUTE : Y Signal Route : C Signal Route 3. 3 3. 3 3 Dimension Y/C Separation LSI 3. 3 3. 3 1.8 1.8 1.8 1.8 1.8 1.8 1.8 1.8 1.8 3.0 2.5 1.8 2.2 1.8 2.2 2.2 2.2 1.8 2.2 2.2 1.8 2.2 2.2 2.2 2.2 2.2 2.2...
Page 136 64LHP5000 PROJECTOR UNIT Ë SIGNAL ASSY (2/9) CN204 E3 SIGNAL ASSY(2/9) (AWV1725) • COLOR DECORD BLOCK (1) IC7102: VIDEO 8/9,9/9 11.3 11.3 IC7101: MAIN CCY SW VIDEO AMP IC7100 (TA1270AF-K) Voltege(V) Voltege(V) Voltege(V) Voltege(V) Voltege(V) Voltege(V)
Page 137 64LHP5000 PROJECTOR UNIT (R-Y) IC7100 : MAIN COLOR DECORD LSI 3. 3 (R-Y) (B-Y) (B-Y) 4. 6 4. 0 (B-Y) 4. 6 4. 0 SIGNAL ROUTE : Y Signal Route : C Signal Route : RED Signal Route (R-Y) (B-Y)
Page 138 64LHP5000 PROJECTOR UNIT Ë SIGNAL ASSY (3/9) SIGNAL ASSY(3/9) (AWV1725) • COLOR DECORD BLOCK (2) IC7250: EPG SW (R-Y) (B-Y) 9. 0 9. 0 4. 2 4. 2 4. 2 2. 2 2. 2 4. 2 4. 0 3. 8 9.
Page 139 64LHP5000 PROJECTOR UNIT...
Page 140 64LHP5000 PROJECTOR UNIT Ë SIGNAL ASSY (4/9) 2. 4 SIGNAL ASSY(4/9) (AWV1725) • COLOR DECORD BLOCK (3) 2. 6 2. 6 2. 6 3. 5 2. 4 3. 5 6. 1 5. 4 5. 6 2. 0 4. 8 0. 8 IC7307: 3.
Page 141 64LHP5000 PROJECTOR UNIT 2. 4 2. 4 3. 2 IC7302: VIDEO AMP 2. 6 9. 0 2. 6 2. 6 IC7300: 3. 5 SUB COLOR DECORD LSI 3. 5 2. 0 3. 9 2. 0 2. 0 3. 3 4. 5 4.
Page 142 64LHP5000 PROJECTOR UNIT Ë SIGNAL ASSY (5/9) SIGNAL ASSY(5/9) (AWV1725) • TWIN-P BLOCK (1) (R-Y) (B-Y) (R-Y) (B-Y) 4. 8 4. 8 4. 8...
Page 143 64LHP5000 PROJECTOR UNIT IC7504: MAIN 8bit A/D CONVERTER (R-Y) (B-Y) IC7503: MAIN 8bit A/D CONVERTER IC7505: MAIN 8bit A/D CONVERTER SIGNAL ROUTE : Y Signal Route (R-Y) : RED Signal Route (B-Y) : BLUE Signal Route...
Page 144 64LHP5000 PROJECTOR UNIT Ë SIGNAL ASSY (6/9) SIGNAL ASSY(6/9) (AWV1725) • TWIN-P BLOCK (2) 3. 6 2. 0 2. 6 CN5607...
Page 145 64LHP5000 PROJECTOR UNIT 1. 8 1. 8 1. 8 IC7602: SUB 8bit A/D CONVERTER 1. 8 1. 4 1. 8 2. 6 IC7601: SUB 8bit A/D CONVERTER 2. 6 1. 8 IC7603: SUB 8bit A/D CONVERTER...
Page 146 64LHP5000 PROJECTOR UNIT Ë SIGNAL ASSY (7/9) 0. 8 0. 8 0. 8 1. 4 IC7701, 7702: 2. 4 0. 8 3. 2 0. 8 0. 8 4M DRAM 0. 8 0. 8 0. 8 3. 2 1. 6 1. 6 1.
Page 147 64LHP5000 PROJECTOR UNIT 0. 8 0. 8 0. 8 3. 2 0. 8 0. 8 SIGNAL ASSY(7/9) (AWV1725) 3. 2 • TWIN-P BLOCK (3) 1. 6 1. 6 0. 8 1. 6 0. 8 0. 8 0. 8 1. 6 1.
Page 148 64LHP5000 PROJECTOR UNIT Ë SIGNAL ASSY (8/9) SIGNAL ASS • µ-COM BLOC (Not used) IC7801: IC7802: RESET IC E P ROM CN5603 (B-Y) (R-Y)
Page 149 64LHP5000 PROJECTOR UNIT SIGNAL ASSY(8/9) (AWV1725) • µ-COM BLOCK PDOWN CONTROL µ-COM SIGNAL ROUTE : Y Signal Route (R-Y) : RED Signal Route (B-Y) : BLUE Signal Route...
Page 150 64LHP5000 PROJECTOR UNIT Ë SIGNAL ASSY (9/9) SIGNAL ASSY (AWV1725) • EPG BLOCK IC7901: 4MPROM 1. 4 2. 2 2. 4 2. 2 3. 3 2. 6 1. 8 2. 4 4. 6 4. 6 J5026 3. 6 EPG DECORD LSI 4.
Page 151 64LHP5000 PROJECTOR UNIT 3. 2 3. 2 2. 2 2. 2 3. 2 3. 2 3. 2 2. 2 IC7901: 4MPROM 3. 2 1. 6 3. 2 1. 4 2. 2 2. 6 0. 6 3. 8 2. 4 2. 4 2.
Page 152 64LHP5000 PROJECTOR UNIT Ë AMP ASSY (1/3) IC905, Q908, Q909, Q921: AMP ASSY(1/3) (AWV1712) • CONVERGENCE/V.DEF BLOCK H PULSE CANCEL 1. 3 1. 4 8. 8 0. 9 0. 9 0. 3 –7. 4 –5 CN206 2. 6 1. 2 4.
Page 153 64LHP5000 PROJECTOR UNIT 9, Q921: IC911, IC912, Q904-Q907, Q922: CONVERGENCE H. BLOCK Note: As for voltages of IC903-IC913 refer to page 157. 0. 9 IC913: 1. 2 0. 6 VIDEO MUTE (H) 0. 7 0. 6 0. 4 DEFLECTION YORK (H, V) L3 (B) Q1137-Q1139: V.
Page 154 64LHP5000 PROJECTOR UNIT Ë AMP ASSY (2/3) AMP ASSY(2/3) (AWV1712) • AUDIO BLOCK IC1205: SURROUND GA SELECTOR IC1204: SURROUND 12. 1 IC1201: VOLUME, TONE and BALANCE CONTROL CN2205 Q1205, Q1222: CN6403 MUTE DRIVER Q1202, Q1203: MUTE SIGNAL RO : Audio S...
Page 155 64LHP5000 PROJECTOR UNIT IC1205: * TruSurround, SRS and the SRS symbol are trademarks of SURROUND GAIN SRS Labs, Inc. TruSurround and SRS are incorporated SELECTOR under a license from SRS Labs, Inc. Patented in the U.S. and selected countries. IC1204:...
Page 156 64LHP5000 PROJECTOR UNIT Ë AMP ASSY (3/3) AMP ASSY(3/3) (AWV1712) • EXP BLOCK...
Page 157 64LHP5000 PROJECTOR UNIT AMP ASSY (1/3) IC905 (NJM072BD) IC907 (CA0007AD) IC903 (STK392-040) IC904 (STK392-040) Voltage Voltage Voltage Voltage Voltage Voltage Voltage Voltage –23.3 –23.3 –21.8 –21.7 –22.8 –22.8 –21.8 –21.7 22.7 22.7 –22.3 –22.2 –5.0 23.5 23.6 –23.8 –23.6 IC906 (M5220P) –23.8...
Page 158 64LHP5000 PROJECTOR UNIT Ë CONVER.DAC ASSY, CONNECTOR ASSY IC1402: IC1401: V.CONVERGENCE CONVER.DAC ASSY (AWV6333 H.CONVERGENCE CORRECTION CORRECTION WAVE FROM WAVE FROM GENERATOR GENERATOR –0. 7 –0. 7 –0. 9 –0. 9 –1. 5...
Page 159 64LHP5000 PROJECTOR UNIT F-b G Guide page Large size SCH diagram Detailed page ASSY (AWV6333) 4. 4 CONNECTOR 0. 6 ASSY (AWZ6335) CN905 CN906 Note: As for voltages of IC1401-IC1406 and IC1408-IC1412 refer to page 197. IC1405, IC1406 9 , 10...
Page 160 IC1402: IC1401: V.CONVERGENCE CONVER.DAC ASSY (AW H.CONVERGENCE CORRECTION CORRECTION WAVE FROM WAVE FROM GENERATOR GENERATOR –0. 7 –0. 7 –0. 9 –0. 9 –1. 5...
Page 161 64LHP5000 PROJECTOR UNIT...
Page 162 (AWV6333) 4. 4 CONNECTOR 0. 6 ASSY (AWZ6335) CN905...
Page 163 CN906 Note: As for voltages of IC1401-IC1406 and IC1408-IC1412 refer to page 197. IC1405, IC1406 9 , 10 (CN1402 (H2) 1 - 3 ) SIGNAL ROUTE : V.deflection Signal Route...
Page 164 64LHP5000 PROJECTOR UNIT Ë SR BNC ASSY, FRONT INPUT ASSY, FRONT CONTROL ASSY, LED DPO ASSY, SR ASSY FRONT (AWZ63 SR BNC ASSY (AWZ6351) CN5071 CN2213 CN2209 FRONT INPUT ASSY (AWZ6339) CN6008 13.5 13.5 H I J...
Page 165 64LHP5000 PROJECTOR UNIT CONTROL ASSY LED DPO ASSY (AWZ6348) 337) 1177 12. 5 10.0 SR ASSY (AWZ6350) CN5023 J K M...
Page 166 64LHP5000 PROJECTOR UNIT Ë AV I/O ASSY (1/3) • A SELECTOR MONITOR CN5041 4. 5 6. 5 6. 5 5. 9 5. 9...
Page 167 64LHP5000 PROJECTOR UNIT SIGNAL ROUTE : Video Signal Route : Audio Signal Route : Y Signal Route AV I/O ASSY(1/3) (AWV1722) : C Signal Route • AV I/O BLOCK 4. 3~6. 3 3. 2 (TV1) (TV1.L) J2703 3. 2 4. 3~6. 3 3.
Page 168 64LHP5000 PROJECTOR UNIT Ë AV I/O ASSY (2/3) AV I/O ASSY(2/3) (AWV1722) • COMPONENT BLOCK DTV SET TOP BOX SH-D07 3. 3 3. 3 3. 3 3. 3 3. 3 3. 3...
Page 169 64LHP5000 PROJECTOR UNIT 4. 2 4. 2 4. 2 Q6228, Q6232, Q6231, Q6202, Q6212, Q6205,Q6207, Q6209, Q6211: MUTE 4. 3 3. 6 4. 3 CN5608 3. 3 3. 3 3. 3 3. 3 3. 3 2. 7...
Page 170 64LHP5000 PROJECTOR UNIT Ë AV I/O ASSY (3/3) AV I/O ASSY(3/3) (AWV1722) • SOUND BLOCK 5. 5 CN1201...
Page 171 64LHP5000 PROJECTOR UNIT CN6404 CN5602 SIGNAL ROUTE : Audio Signal Route...
Page 172 64LHP5000 PROJECTOR UNIT Ë AC IN ASSY AC IN ASSY (AWZ6354) DTV SET TOP BOX TO AC POWER CORD SH-D07 ATT1282 FU102: REK1082 FU104: AEK1010 FU101: AEK1069 CN202 IC102: IN RASH KILLER PROTECTOR Q101,102:RELAY DRIVE Q103,104: RELAY DRIVE...
Page 173 64LHP5000 PROJECTOR UNIT • NOTE FOR FUSE REPLACEMENT CAUTION – FOR CONTINUED PROTECTION AGAINST RISK OF FIRE, REPLACE ATT1282 ONLY WITH SAME TYPE AND RATINGS ONLY. FU103: AEK1011 CN208 CN201 IC101:IN RASH KILLER PROTECTOR ELAY DRIVE Q105,106:P.D HOLD...
Page 174 64LHP5000 PROJECTOR UNIT Ë R CRT DRIVE ASSY, G CRT DRIVE ASSY, B CRT DRIVE ASSY R CRT DRIVE ASSY (AWZ6344) G CRT DRIVE ASSY CN307 CN5251 CRT STAND RED VM COIL CN801 R CRT G CRT DRIVE ASSY (AWZ6345)
Page 175 64LHP5000 PROJECTOR UNIT G CRT B CRT DRIVE ASSY (AWZ6346) DRIVE ASSY BLUE CN5251 CRT STAND BLUE VM COIL CN801 SIGNAL ROUTE :R,G or B SIGNAL P Q R...
Page 176 64LHP5000 PROJECTOR UNIT Ë DEFLECTION SERVICE ASSY (1/3) CN5102 CN2201 CN3803 Y1 CN907 G1 VR302:VRTHS6VS473 11.9 11.9 VR303: VRTB6VS223 Q304,Q305,Q306,Q307: V.BLK GENERATOR 12.7 Q325:12V DOWN DETECTOR IC301:DEF IC. REGUL Q302:HV.PRE Q318,Q319:H.SIZE ADJ DC B Q301:H.OSC SW DRIVE Q313: VR301: Q310,Q H.DEF STOP...
Page 177 64LHP5000 PROJECTOR UNIT 5102 CN205 DEFLECTION SERVICE ASSY(1/3) (AWV1731) CN203 E7 • H. DEF BLOCK R422 13.5 Q326,Q327:PD HOLD Q303:PD KILLER Q315,Q316: OVER CURRENT 134.2 PROTECTOR 134.6 133.6 73.9 12.7 12.7 12.7 134.7 Q314,Q324: 107.2 H.DEF REGULATOR 106.6 IC302: L1(R) REGULATOR 66.5...
Page 178 64LHP5000 PROJECTOR UNIT Ë DEFLECTION SERVICE ASSY (2/3) DEFLECTION SERVICE ASSY(2/3) (AWV1731) • HV BLOCK FOCUS Q751,Q752, Q753,Q754: DYNAMIC FOCUS 11.4 11.5 15.4 15.1 225.3 31.9 212.1 -0.1 210.3 Q601:HV.DRIV Q614:DRIVE MUTE 13.2 125.9 11.9 Q611:210V DOWN Q609,Q610:210V DETECTOR REGULATOR...
Page 179 64LHP5000 PROJECTOR UNIT WV1731) 11.3 134.4 Q607,Q608: Q604 X-RAY DETECTOR Q605:OVER CURRENT PROTECTOR 133.9 134.6 48.1 Not use IC601,Q602,Q603:HV.CONTROL 134.6 Not use 75.4 112.1 112.4 Q606,Q613: HV.REGURATOR 111.5 0.56 111.1 110.6 HV.CR BLOCK 15.1 FOCUS 31.9 VR(VR1) -0.1 Q612: 24.1 HV:OUT 13.4...
Page 180 64LHP5000 PROJECTOR UNIT Ë DEFLECTION SERVICE ASSY (3/3) DEFLECTION SERVICE ASSY(3/3) (AWV1731) • VM BLOCK...
Page 181 64LHP5000 PROJECTOR UNIT 1731) CN5106 CN5157 CN5207...
Page 182 64LHP5000 PROJECTOR UNIT Ë POWER SUPPLY ASSY IC201: SWITCHING CONTROL CN103 14.5 Q201: SWITCHING FU101: AEK1069 13.2 IC202,Q203: 14.5V CONTROL CN104 FU201: REK1085 FU202: REK1085 FU203: REK1082 FU204: REK1083 FU205: REK1079 FU206: REK1083 IC207: SWITCHING CONTROL 13 14 15 5A/125V –7.5...
Page 183 64LHP5000 PROJECTOR UNIT POWER SUPPLY ASSY (AWV1710) IC203: 9V(1) REGULATOR Q204: IC208: Q209: 14.5 9V(2) HEATER 13.5V(2) REGULATOR 1.25 REGULATOR SWITCH PROTECTOR IC204: 13.5V(2) 13.5 REGULATOR J7100 1.25 ASR1050A- IC206: HEATER REGULATOR C202,Q203: CN5601 V CONTROL 1.25 Q212: RELAY DRIVE...
Page 184 64LHP5000 PROJECTOR UNIT...
Page 185 64LHP5000 PROJECTOR UNIT...
Page 186 64LHP5000 PROJECTOR UNIT...
Page 187 64LHP5000 PROJECTOR UNIT...
Page 188 64LHP5000 PROJECTOR UNIT...
Page 189 64LHP5000 PROJECTOR UNIT...
Page 190 64LHP5000 PROJECTOR UNIT...
Page 191 64LHP5000 PROJECTOR UNIT...
Page 192 64LHP5000 PROJECTOR UNIT...
Page 193 64LHP5000 PROJECTOR UNIT...
Page 194 64LHP5000 PROJECTOR UNIT...
Page 195 64LHP5000 PROJECTOR UNIT...
Page 196 64LHP5000 PROJECTOR UNIT...
Page 197 64LHP5000 PROJECTOR UNIT...
Page 198 64LHP5000 PROJECTOR UNIT...
Page 199 64LHP5000 PROJECTOR UNIT PCB CONNECTION DIAGRAM NOTE FOR PCB DIAGRAMS : 1. Part numbers in PCB diagrams match those in the schematic diagrams. 2. A comparison between the main parts of PCB and schematic diagrams is shown below. Symbol In PCB...
Page 200 64LHP5000 PROJECTOR UNIT Ë TUNER u-COM ASSY...
Page 201 64LHP5000 PROJECTOR UNIT...
Page 202 64LHP5000 PROJECTOR UNIT...
Page 203 64LHP5000 PROJECTOR UNIT...
Page 204 64LHP5000 PROJECTOR UNIT Ë VIDEO ASSY...
Page 205 64LHP5000 PROJECTOR UNIT Guide page Large size SCH diagram Detailed page...
Page 206 64LHP5000 PROJECTOR UNIT...
Page 207 64LHP5000 PROJECTOR UNIT...
Page 208 64LHP5000 PROJECTOR UNIT...
Page 209 64LHP5000 PROJECTOR UNIT...
Page 210 64LHP5000 PROJECTOR UNIT...
Page 211 64LHP5000 PROJECTOR UNIT...
Page 212 64LHP5000 PROJECTOR UNIT Ë SUB VIDEO ASSY...
Page 213 64LHP5000 PROJECTOR UNIT...
Page 214 64LHP5000 PROJECTOR UNIT...
Page 215 64LHP5000 PROJECTOR UNIT...
Page 216 64LHP5000 PROJECTOR UNIT Ë SIGNAL ASSY...
Page 217 64LHP5000 PROJECTOR UNIT...
Page 218 64LHP5000 PROJECTOR UNIT...
Page 219 64LHP5000 PROJECTOR UNIT...
Page 220: Pcb Connection Diagram
64LHP5000 PROJECTOR UNIT Ë AMP ASSY AMP ASSY DEFLECTION YORK(H,V) CN2206 T4 CN6403 A IC6651 Q1138 Q1137 Q921 Q908 Q924 IC903 Q913 Q912 Q907 IC902 Q905 Q909 Q910 Q915 Q916 Q922 IC901 Q904 IC913 IC905 IC1210 IC1203 Q923 IC911 Q903...
Page 221 64LHP5000 PROJECTOR UNIT CN1804 C2 SIDE A CN1803 C1 Y1202 YJ5HA0-08-5/5 J1201 YJ5HA0-06-5/5 Y1203 YJ5HA0-06-5/5 TO SPEAKER CN211 E4 CN6403 A1 IC904 Q901 IC907 Q1208 Q1133 Q1132 Q1134 Q1139 IC906 Q902 IC1206 Q1206 Q1135 Q1136 Q1131 Q1205 IC1201 Q1211 IC1207...
Page 222 64LHP5000 PROJECTOR UNIT Ë CONVER.DAC ASSY, CONNECTOR ASSY CONVER.DAC ASSY IC1403 IC1412 IC1411 IC1408 IC1409 IC1410...
Page 223 64LHP5000 PROJECTOR UNIT SIDE A CONNECTOR ASSY SIDE A Q1403 Q1405 IC1402 Q1404 Q1406 Q1401 Q1407 Q1408 Q1402 IC1401...
Page 224 64LHP5000 PROJECTOR UNIT CONVER.DAC ASSY...
Page 225 64LHP5000 PROJECTOR UNIT SIDE B IC1404 Q1410 IC1405 Q1409...
Page 226 64LHP5000 PROJECTOR UNIT Ë FRONT CONTROL ASSY FRONT CONTROL ASSY SIDE A CN5001 CN2209 T6 FRONT CONTROL ASSY SIDE B...
Page 227 64LHP5000 PROJECTOR UNIT Ë LED DPO ASSY LED DPO ASSY SIDE A VR5001 Q5005 Q5003 Q2004 Q2005 Q5001 LED DPO ASSY SIDE B...
Page 228 64LHP5000 PROJECTOR UNIT Ë FRONT INPUT ASSY FRONT INPUT ASSY CN6008 A2 SIDE A FRONT INPUT ASSY SIDE B Q5041 Q5042...
Page 229 64LHP5000 PROJECTOR UNIT Ë SR ASSY CN5203 V1 SR ASSY SIDE A SR ASSY SIDE B...
Page 230 64LHP5000 PROJECTOR UNIT AV I/O ASSY Ë AV I/O ASSY...
Page 231 64LHP5000 PROJECTOR UNIT SIDE A...
Page 232 64LHP5000 PROJECTOR UNIT J2703 T9 AV I/O ASSY J700 CN5041 F1 DTV SET TOP BOX...
Page 233 64LHP5000 PROJECTOR UNIT CN1201 G6 SIDE B J7001 X4 CN209 E2 T TOP BOX CN5608 U9...
Page 234 64LHP5000 PROJECTOR UNIT Ë AC IN ASSY CN201 E9 AC IN ASSY CN202 E10 Q105 Q101 Q102 Q104 IC102 IC101 Q106 Q103...
Page 235 64LHP5000 PROJECTOR UNIT DTV SET TOP BOX SIDE A...
Page 236 64LHP5000 PROJECTOR UNIT Ë R CRT DRIVE ASSY R CRT DRIVE ASSY SIDE A CN5251 U2 J5152 VR5101 IC5101 RED VM COIL CN307 K4 CN801 K5 SIDE B...
Page 237 64LHP5000 PROJECTOR UNIT Ë G CRT DRIVE ASSY G CRT DRIVE ASSY SIDE A CN5251 U2 J5152 J5203 VR5151 IC5151 GREEN VM COIL CN801 K5 SIDE B...
Page 238 64LHP5000 PROJECTOR UNIT Ë B CRT DRIVE ASSY B CRT DRIVE ASSY SIDE A CN5251 U2 J5203 VR5201 IC5201 BLUE VM COIL CN801 K5 SIDE B...
Page 239 64LHP5000 PROJECTOR UNIT Ë SR BNC ASSY, R CRT DRIVE ASSY SR BNC ASSY SIDE A SR BNC ASSY SIDE B...
Page 240 64LHP5000 PROJECTOR UNIT Ë DEFLECTION SERVICE ASSY H. DETECTION Y CRT STAND DEFLECTION SERVICE ASSY HV CR BLOCK FOCUS CN1203 E7 VR601 VR602 Q612 Q601 Q614 Q608 Q603 Q324 Q309 Q308 Q605 Q607 Q314 IC601 Q602 Q606 Q613...
Page 241 64LHP5000 PROJECTOR UNIT DETECTION YORK CN907 G1 CN2201 T1 CN3803 Y1 FOCUS VR VR303 R320 CN1203 E7 CN5102 M3 VR603 VR301 VR302 Q308 Q605 Q315 Q311 Q310 Q751 Q326 Q754 IC302 Q318 Q303 Q301 Q320 IC301 Q307 Q305 Q804 Q322...
Page 242 64LHP5000 PROJECTOR UNIT Ë POWER SUPPLY ASSY POWER SUPPLY ASSY VR202 VR201 IC205 Q202 IC207 Q203 IC201 IC202...
Page 243 J7100 X1 CN309 K12 J101 D1 CN304 K1 CN5081 X1 CN1206 G18 CN5601 U1...
Page 244: Electrical Parts
5.62k Ω → 562 × 10 → 5621 ..RN1/4PC 5 6 2 1 in USA: Contact your nearest SHARP Parts Distributor. • Parts marked by are important parts which relate in X-rays For location of SHARP Parts Distributor, radiation.
Page 245 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1710 D254 9GJ1SS254 M Diode D255 9GJRD5.1ESB M Zener Diode POWER SUPPLY ASSY (Continued) D256 9GJ1SS254 M Diode DIODES D257 9GJ1SS254 M Diode...
Page 246 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1710 C274 9GJCKCYB103K50 M Ceramic C275 9GJCEHAT102M63 M Elect. POWER SUPPLY ASSY (Continued) C276 9GJCKCYB103K50 M Ceramic C221 9GJCQMA333J50 M Mylar Film C277...
Page 247 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1710 å FU202 9GJREK1085 M Fuse 6.3A å FU203 9GJREK1082 M Fuse 4A POWER SUPPLY ASSY (Continued) å FU204 9GJREK1083 M Fuse 5A...
Page 248 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1711 Q804 9GJ2SA1145 M Transistor Q805 9GJ2SC2705 M Transistor DEFLECTION SERVICE ASSY Q806 9GJ2SA1145 M Transistor INTEGRATED CIRCUITS Q807 9GJ2SC2705 M Transistor å...
Page 249 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1711 C310 9GJCEHAT470M25 M Elect. C311 9GJCKCYB102K50 M Ceramic DEFLECTION SERVICE ASSY (Continued) C312 9GJCFTXA224J50 M Audio Film D625 9GJ1SS254 M Diode C313 9GJCEHAT331M16 M Elect.
Page 250 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1711 C819 9GJCKCYE103P2H M Ceramic C820 9GJCCCSL220J50 M Ceramic DEFLECTION SERVICE ASSY (Continued) C821 9GJCCCSL220J50 M Ceramic C606 9GJCCCSL101J50 M Ceramic C822 9GJCCCSL220J50 M Ceramic...
Page 251 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1711 R415 9GJRD1/4PU102J M Carbon Film R416 9GJRD1/4PU103J M Carbon Film DEFLECTION SERVICE ASSY (Continued) R417 9GJRD1/4PU471J M Carbon Film R358 9GJRS2MMF2R2J M Metal Oxide...
Page 252 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1711 R812 9GJRD1/4PU101J M Carbon Film R813 9GJRD1/2PM270J M Carbon Film DEFLECTION SERVICE ASSY (Continued) R814 9GJRD1/2PM270J M Carbon Film R653 9GJRD1/4PU223J M Carbon Film...
Page 253 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1712 Q1202 9GJ2SC2878 M Transistor Q1203 9GJ2SC2878 M Transistor AMP ASSY Q1205 9GJ2SA933S M Transistor INTEGRATED CIRCUITS Q1206 9GJ2SC1740S M Transistor IC901 9GJNJM7805FA...
Page 254 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1712 C904 9GJCKCYF103Z50 M Ceramic C905 9GJCEHAT101M16 M Elect. AMP ASSY (Continued) C906 9GJCKCYF103Z50 M Ceramic D1132 9GJBR3371XJ30A M LED C907 9GJCEHAT331M63 M Elect.
Page 255 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1712 C1142 9GJCKCYF103Z50 M Ceramic C1143 9GJCKCYF103Z50 M Ceramic AMP ASSY (Continued) C1144 9GJCKCYF103Z50 M Ceramic C965 9GJCEHAT101M10 M Elect. C1171 9GJCKCYF103Z50 M Ceramic C966 9GJCEHAT101M10 M Elect.
Page 256 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1712 R924 9GJRS1MMFR47J M Metal Oxide R925 9GJRD1/4PU101J M Carbon Film AMP ASSY (Continued) R926 9GJRD1/4PU221J M Carbon Film C1265 9GJCFTYA104J50 M Audio Film...
Page 257 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1712 R1046 9GJRS2MMF1R5J M Metal Oxide R1047 9GJRD1/4PU221J M Carbon Film AMP ASSY (Continued) R1048 9GJRD1/4PU221J M Carbon Film R982 9GJRN14PC2200F M Metal Film...
Page 258 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1712 R1246 9GJRD1/4PU101J M Carbon Film R1263 9GJRD1/4PU103J M Carbon Film AMP ASSY (Continued) R1264 9GJRD1/4PU101J M Carbon Film R1147 9GJRD1/4PU223J M Carbon Film...
Page 259 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1721 9GJAWV1712 CONV. DAC ASSY AMP ASSY (Continued) RESISTOR R1354 9GJRD1/4PU333J M Carbon Film R1355 9GJRD1/4PU222J M Carbon Film R5093 9GJRS1/16S0R0J M Chip...
Page 260 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWZ6333 C1462 9GJCEV101M6R3 M Chip Elect. C1463 9GJCCSQCH101J5 M Chip CONVER. DAC ASSY (Continued) C1464 9GJCCSQCH101J5 M Chip C1404 9GJCEV330M10 M Chip Elect.
Page 261 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWZ6333 R1454 9GJRS1/16S104J M Chip R1455 9GJRS1/16S104J M Chip CONVER. DAC ASSY (Continued) R1456 9GJRS1/16S622J M Chip RESISTORS R1457 9GJRS1/16S101J M Chip R1401 9GJRS1/16S102J...
Page 262 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWZ6333 R1569 9GJRS1/16S101J M Chip R1570 9GJRS1/16S101J M Chip CONVER. DAC ASSY (Continued) R1571 9GJRS1/16S101J M Chip R1512 9GJRS1/16S222J M Chip R1572 9GJRS1/16S101J...
Page 263 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWZ6333 R1681 9GJRS1/16S101J M Chip R1682 9GJRS1/16S101J M Chip CONVER. DAC ASSY (Continued) R1683 9GJRS1/16S101J M Chip R1627 9GJRS1/16S103J M Chip R1684 9GJRS1/16S101J...
Page 264 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWZ6333 9GJAWZ6337 CONVER. DAC ASSY (Continued) FRONT CONTROL ASSY CAPACITORS R1756 9GJRS1/16S104J M Chip R1757 9GJRS1/16S334J M Chip C5003 9GJCEV101M6R3 M Chip Elect.
Page 265 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWZ6339 9GJAWZ6348 FRONT INPUT ASSY LED DPO ASSY TRANSISTORS TRANSISTORS Q5041 9GJ2SC2712 M Transistor Q5001 9GJ2SA1162 M Chip TR Q5042 9GJ2SC2712 M Transistor...
Page 266 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWZ6350 9GJAWZ6351 SR ASSY SR BNC ASSY PACKAGED CIRCUIT TRANSISTORS X5071 9GJGP1U281X Q5021 9GJ2SC2712 M Transistor Q5022 9GJ2SC2712 M Transistor CAPACITORS Q5023 9GJ2SA1162...
Page 267 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1722 Q6213 9GJ2SA1162 M Chip TR Q6214 9GJ2SA1162 M Chip TR AV I/O ASSY Q6215 9GJ2SA1162 M Chip TR INTEGRATED CIRCUITS Q6216 9GJ2SA1162...
Page 268 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1722 D6405 9GJ1SS184 M Diode(SMD) D6406 9GJ1SS226 M Diode AV I/O ASSY (Continued) D6407 9GJ1SS352 M Diode(SMD) DIODES D6408 9GJ1SS352 M Diode(SMD) D6001 9GJ1SS226 M Diode D6409 9GJRD3.6MB...
Page 269 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1722 C6228 9GJCEV100M16 M Chip Elect. C6229 9GJCEV4R7M35 M Chip Elect. AV I/O ASSY (Continued) C6231 9GJCKSQYF103Z5 M Chip C6062 9GJCEV102M6R3 M Chip Elect.
Page 270 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1722 R6075 9GJRS1/16S221J M Chip R6076 9GJRD1/2LMF1R0J M Carbon Film AV I/O ASSY (Continued) R6077 9GJRS1/16S222J M Chip R6009 9GJRS1/16S222J M Chip R6078 9GJRS1/16S222J...
Page 271 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1722 R6231 9GJRS1/16S123J M Chip R6232 9GJRS1/16S123J M Chip AV I/O ASSY (Continued) R6233 9GJRS1/16S123J M Chip R6173 9GJRS1/16S101J M Chip R6234 9GJRS1/16S222J...
Page 272 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1722 R6357 9GJRS1/16S470J M Chip R6358 9GJRS1/16S104J M Chip AV I/O ASSY (Continued) R6359 9GJRS1/16S101J M Chip R6298 9GJRS1/16S101J M Chip R6360 9GJRS1/16S104J...
Page 273 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1722 9GJAWV1723 TUNER µ-COM ASSY AV I/O ASSY (Continued) INTEGRATED CIRCUITS R6435 9GJRS1/16S223J M Chip R6436 9GJRS1/16S223J M Chip IC2201 9GJPD5462D9 M TV CON. MICRO-COMP...
Page 274 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1723 D2230 9GJ1SS226 M Diode TUNER µ-COM ASSY (Continued) D2231 9GJ1SS226 M Diode D2232 9GJ1SS226 M Diode Q2705 9GJ2SC2712 M Transistor D2233 9GJ1SS226...
Page 275 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1723 D2703 9GJ1SS226 M Diode TUNER µ-COM ASSY (Continued) D2704 9GJ1SS226 M Diode D2705 9GJRD15MB M Zener Diode D2287 9GJ1SS226 M Diode D2706 9GJRD15MB...
Page 276 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1723 C2707 9GJCEAT4R7M50 M Elect. TUNER µ-COM ASSY (Continued) C2708 9GJCFTXA224J50 M Audio Film C2709 9GJCEAT1R0M50 M Elect. C2221 9GJCKSQYB561K5 M Ceramic C2710 9GJACH1128-A M Elect.
Page 277 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1723 R2251 9GJRS1/16S223J M Chip TUNER µ-COM ASSY (Continued) R2252 9GJRS1/16S332J M Chip R2253 9GJRS1/16S221J M Chip C2821 9GJCEAT100M50 M Elect. R2254 9GJRS1/16S102J...
Page 278 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1723 R2362 9GJRS1/16S272J M Chip TUNER µ-COM ASSY (Continued) R2363 9GJRS1/16S101J M Chip R2364 9GJRS1/16S272J M Chip R2308 9GJRS1/16S101J M Chip R2365 9GJRS1/16S272J...
Page 279 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1723 R2474 9GJRS1/16S823J M Chip TUNER µ-COM ASSY (Continued) R2475 9GJRS1/16S223J M Chip R2476 9GJRS1/16S221J M Chip R2419 9GJRS1/16S333J M Chip R2477 9GJRS1/16S183J...
Page 280 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1723 R2725 9GJRS1/16S561J M Chip TUNER µ-COM ASSY (Continued) R2726 9GJRS1/16S562J M Chip R2727 9GJRS1/16S153J M Chip R2537 9GJRS1/16S182J M Chip R2728 9GJRS1/16S183J...
Page 281 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1723 CN220 9GJKM250MA8LR M L-Plug(8P) TUNER µ-COM ASSY (Continued) CN221 9GJKM250MA3LR M Plug 3-P J2702 9GJADX2497 M 4P Housing Wire R2787 9GJRS1/16S223J M Chip...
Page 282 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1724 Q5293 9GJ2SA933S M Transistor Q5294 9GJ2SA933S M Transistor VIDEO ASSY Q5295 9GJ2SA933S M Transistor INTEGRATED CIRCUITS Q5296 9GJ2SA933S M Transistor IC5251 9GJTA1276AN...
Page 283 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1724 D5326 9GJMTZJ11 M Zener Diode D5327 9GJMTZJ11 M Zener Diode VIDEO ASSY (Continued) D5328 9GJMTZJ11 M Zener Diode D5271 9GJ1SS254 M Diode...
Page 284 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1724 L5601 9GJATX1008-A M Ferrite Bead L5602 9GJATH-059 M Coil VIDEO ASSY (Continued) L5603 9GJATH-059 M Coil D5628 9GJ1SS254 M Diode L5604 9GJATH-059...
Page 285 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1724 C5619 9GJCEAT222M16 M Elect. C5620 9GJCEAT101M16 M Elect. VIDEO ASSY (Continued) C5621 9GJCKCYF103Z50 M Ceramic C5299 9GJCCCCH4R0C50 M Ceramic C5622 9GJCEAT471M16 M Elect.
Page 286 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1724 R5343 9GJRD1/4PU113J M Carbon Film R5344 9GJRD1/4PU562J M Carbon Film VIDEO ASSY (Continued) R5345 9GJRD1/4PU303J M Carbon Film R5287 9GJRD1/2PM101J M Carbon Film...
Page 287 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1724 R5470 9GJRD1/4PU153J M Carbon Film R5471 9GJRD1/4PU101J M Carbon Film VIDEO ASSY (Continued) R5472 9GJRD1/4PU681J M Carbon Film R5412 9GJRD1/4PU102J M Carbon Film...
Page 288 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1724 R5667 9GJRD1/4PU101J M Carbon Film R5668 9GJRD1/4PU101J M Carbon Film VIDEO ASSY (Continued) R5669 9GJRD1/4PU101J M Carbon Film R5607 9GJRD1/4PU101J M Carbon Film...
Page 289 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1724 9GJAWV1725 VIDEO ASSY (Continued) SIGNAL ASSY INTEGRATED CIRCUITS R5727 9GJRD1/4PU103J M Carbon Film R5728 9GJRD1/4PU470J M Carbon Film IC7001 9GJMC14577CF M Video Amp IC...
Page 290 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1725 Q7312 9GJ2SC2712 M Transistor Q7313 9GJ2SC2712 M Transistor SIGNAL ASSY (Continued) Q7314 9GJ2SC2712 M Transistor IC7901 RH-IX3273CEZZ M 4MPROM Q7315 9GJ2SC2712 M Transistor...
Page 291 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1725 L7002 9GJQTL1013 M Chip Solid Inductor L7003 9GJQTL1013 M Chip Solid Inductor SIGNAL ASSY (Continued) L7004 9GJQTL1013 M Chip Solid Inductor D7800 9GJ1SS184...
Page 292 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1725 C7006 9GJCKSQYF104Z5 M Ceramic C7007 9GJCKSQYF104Z5 M Ceramic SIGNAL ASSY (Continued) C7008 9GJCCSQSL391J5 M Chip L7633 9GJQTL1013 M Chip Solid Inductor C7009 9GJCKSQYF104Z5 M Ceramic...
Page 293 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1725 C7257 9GJCKSQYF104Z5 M Ceramic C7258 9GJCKSQYF104Z5 M Ceramic SIGNAL ASSY (Continued) C7259 9GJCKSQYF104Z5 M Ceramic C7109 9GJCEV470M6R3 M Chip Elect. C7260 9GJCKSQYF104Z5 M Ceramic C7110 9GJCEV100M16 M Chip Elect.
Page 294 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1725 C7542 9GJCEV470M16 M Chip Elect. C7543 9GJCEV470M16 M Chip Elect. SIGNAL ASSY (Continued) C7544 9GJCEV470M16 M Chip Elect. C7353 9GJCKSQYF103Z5 M Chip C7545 9GJCEV100M16 M Chip Elect.
Page 295 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1725 C7768 9GJCKSQYF104Z5 M Ceramic C7769 9GJCKSQYF104Z5 M Ceramic SIGNAL ASSY (Continued) C7770 9GJCKSQYF104Z5 M Ceramic C7703 9GJCCSQCH101J5 M Chip C7771 9GJCKSQYF104Z5 M Ceramic...
Page 296 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1725 R7048 9GJRS1/16S271J M Chip R7049 9GJRS1/16S271J M Chip SIGNAL ASSY (Continued) R7050 9GJRS1/16S122J M Chip C7933 9GJCEV470M6R3 M Chip Elect. R7051 9GJRS1/16S361J...
Page 297 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1725 R7187 9GJRS1/16S101J M Chip R7188 9GJRS1/16S103J M Chip SIGNAL ASSY (Continued) R7189 9GJRS1/16S122J M Chip R7129 9GJRS1/16S101J M Chip R7190 9GJRS1/16S222J M Chip...
Page 298 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1725 R7364 9GJRS1/16S333J M Chip R7365 9GJRS1/16S471J M Chip SIGNAL ASSY (Continued) R7366 9GJRS1/16S103J M Chip R7284 9GJRS1/16S271J M Chip R7367 9GJRS1/16S122J M Chip...
Page 299 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1725 R7625 9GJRS1/16S152J M Chip R7626 9GJRS1/16S102J M Chip SIGNAL ASSY (Continued) R7627 9GJRS1/16S152J M Chip R7505 9GJRS1/16S102J M Chip R7629 9GJRS1/16S102J M Chip...
Page 300 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1725 R7840 9GJRS1/16S0R0J M Chip R7841 9GJRS1/16S103J M Chip SIGNAL ASSY (Continued) R7842 9GJRS1/16S562J M Chip R7756 9GJRS1/16S561J M Chip R7843 9GJRS1/16S103J M Chip...
Page 301 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1725 R7964 9GJRS1/16S472J M Chip R7965 9GJRS1/16S104J M Chip SIGNAL ASSY (Continued) R7966 9GJRS1/16S561J M Chip R7910 9GJRS1/16S331J M Chip R7967 9GJRS1/16S220J M Chip...
Page 302 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWZ6344 R5116 9GJACN1131-A M “(220, 1/2W)” R5117 9GJRD12LMF100J M Cabon Film R CRT DRIVE ASSY R5118 9GJACN1133-A M “(470 , 1/2W)” INTEGRATED CIRCUIT...
Page 303 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWZ6345 9GJAWZ6346 G CRT DRIVE ASSY (Continued) B CRT DRIVE ASSY C5161 9GJCKCYE103P2H M Ceramic INTEGRATED CIRCUIT C5163 9GJCKCYE103P2H M Ceramic IC5201 9GJTDA6120Q...
Page 304 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWZ6346 D117 9GJ1SS254 M Diode D118 9GJBR3371XJ30A M LED B CRT DRIVE ASSY (Continued) D119 9GJ1SS254 M Diode R5216 9GJRD1/4PU102J M Carbon Film...
Page 305 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWZ6352 9GJAWV1726 AC IN ASSY (Continued) SUB VIDEO ASSY INTEGRATED CIRCUITS R126 9GJRD1/4PU472J M Carbon Film R127 9GJRD1/4PU472J M Carbon Film IC3801 9GJTC74HC4053F M Logic IC...
Page 306 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1726 Q4039 9GJ2SC2712 M Transistor Q4040 9GJ2SC2712 M Transistor SUB VIDEO ASSY (Continued) Q4041 9GJ2SC2712 M Transistor Q3811 9GJ2SC2712 M Transistor Q4042 9GJ2SA1162...
Page 307 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1726 Q4722 9GJ2SA1162 M Chip TR SUB VIDEO ASSY (Continued) DIODES Q4401 9GJ2SA1162 M Chip TR D3801 9GJ1SS226 M Diode Q4402 9GJ2SA1162 M Chip TR...
Page 308 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1726 L4714 9GJLCTA100J322 M Chip Coil L4715 9GJLCTA2R2J322 M Chip Coil SUB VIDEO ASSY (Continued) L4716 9GJLCTA2R2J322 M Chip Coil D4004 9GJ1SS352 M Diode(SMD)
Page 309 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1726 C4022 9GJCCSQCH121J5 M Chip C4023 9GJCEV220M16 M Chip Elect. SUB VIDEO ASSY (Continued) C4024 9GJCKSQYF104Z5 M Ceramic VR4001 9GJVRTS6VS474 M VR C4025 9GJCEV220M16 M Chip Elect.
Page 310 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1726 C4406 9GJCKSQYF103Z5 M Chip C4407 9GJCKSQYF103Z5 M Chip SUB VIDEO ASSY (Continued) C4408 9GJCKSQYF103Z5 M Chip C4081 9GJCCSQCH470J5 M Chip C4409 9GJCKSQYF103Z5 M Chip C4082 9GJCEV470M16 M Chip Elect.
Page 311 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1726 C4752 9GJCKSQYF104Z5 M Ceramic C4753 9GJCKSQYF104Z5 M Ceramic SUB VIDEO ASSY (Continued) C4754 9GJCKSQYF104Z5 M Ceramic C4464 9GJCKSQYB224K1 M Ceramic C4755 9GJCKSQYF104Z5 M Ceramic...
Page 312 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1726 R3820 9GJRS1/16S103J M Chip R3821 9GJRS1/16S473J M Chip SUB VIDEO ASSY (Continued) R3822 9GJRS1/16S152J M Chip C4815 9GJCKSQYF104Z5 M Ceramic R3823 9GJRS1/16S103J...
Page 313 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1726 R3934 9GJRS1/16S101J M Chip R3935 9GJRS1/16S123J M Chip SUB VIDEO ASSY (Continued) R3936 9GJRS1/16S912J M Chip R3877 9GJRS1/16S470J M Chip R3937 9GJRS1/16S102J...
Page 314 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1726 R4100 9GJRS1/16S471J M Chip R4101 9GJRS1/16S392J M Chip SUB VIDEO ASSY (Continued) R4102 9GJRS1/16S0R0J M Chip R4044 9GJRS1/16S392J M Chip R4103 9GJRS1/16S222J...
Page 315 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1726 R4248 9GJRS1/16S223J M Chip R4249 9GJRS1/16S102J M Chip SUB VIDEO ASSY (Continued) R4250 9GJRS1/16S392J M Chip R4165 9GJRS1/16S101J M Chip R4251 9GJRS1/16S163J...
Page 316 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1726 R4375 9GJRS1/16S222J M Chip R4376 9GJRS1/16S101J M Chip SUB VIDEO ASSY (Continued) R4377 9GJRS1/16S153J M Chip R4314 9GJRS1/16S472J M Chip R4378 9GJRS1/16S153J...
Page 317 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1726 R4499 9GJRS1/16S560J M Chip R4500 9GJRS1/16S182J M Chip SUB VIDEO ASSY (Continued) R4501 9GJRS1/16S680J M Chip R4438 9GJRS1/16S102J M Chip R4502 9GJRS1/16S431J...
Page 318 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1726 R4702 9GJRS1/16S562J M Chip R4703 9GJRS1/16S182J M Chip SUB VIDEO ASSY (Continued) R4704 9GJRS1/16S0R0J M Chip R4569 9GJRS1/16S101J M Chip R4706 9GJRS1/16S0R0J...
Page 319 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code 9GJAWV1726 K4001 9GJAKX9002-A M Test Pin K4002 9GJAKX9002-A M Test Pin SUB VIDEO ASSY (Continued) K4003 9GJAKX9002-A M Test Pin R4794 9GJRS1/16S103J M Chip...
Page 320: Cabinet And Mechanical Parts
Code Mark Ref. No. Part No. Description Code Accessory Parts FRONT VIEW (1/2) PARTS LIST Screen Frame 9GJAAM1082 M Badge (SHARP) 9GJANZ-241 M Catcher A 31 Panel Frame H 9GJAEC1394 M Magic Tape (AND1163) Side view 9GJABA1271 M Special Screw...
Page 321 64LHP5000 PROJECTOR UNIT FRONT VIEW (1/2)
Page 322 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code FRONT VIEW (2/2) PARTS LIST 9GJAMR3115 M Lenticular Sheet 64W 9GJANG2312 M Screen Holder Top 64 9GJAMR3123 M Fresnel 64W 9GJANG2000 M Upper Cabinet Metal...
Page 323 64LHP5000 PROJECTOR UNIT FRONT VIEW (2/2)
Page 324 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code REAR VIEW (1/2) PARTS LIST 9GJAME2296 M Mirror Case(51) 9GJABA1240 M Special Screw 9GJPYC40T140FZ M Screw 9GJAMM2929 M Rear Cover 9GJAEC1622 M Blind Sheet (PVC)
Page 325 64LHP5000 PROJECTOR UNIT REAR VIEW (1/2)
Page 326 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code REAR VIEW (2/2) PARTS LIST 9GJAWY1415 M CRT Service Ass’y 64B 9GJAWY1413 M CRT Service Ass’y G 9GJAWY1414 M CRT Service Ass’y 64R...
Page 327 64LHP5000 PROJECTOR UNIT REAR VIEW (2/2)
Page 328 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code CRT BLOCK PARTS LIST 9GJAMR3121 M Lens Ass’y 9GJAWY1414 M CRT Service Ass’y 64R 9GJAWY1413 M CRT Service Ass’y G 9GJAWY1415 M CRT Service Ass’y 64B...
Page 329 64LHP5000 PROJECTOR UNIT CRT BLOCK...
Page 330 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code VIDEO BLOCK PARTS LIST 9GJANA1584 M Video Chassis 9GJAWV1724 M Video Ass’y 9GJAWV1722 M AV I/O Ass’y 9GJANC2322 M Rear Panel (S) 9GJABN-087...
Page 331 64LHP5000 PROJECTOR UNIT VIDEO BLOCK...
Page 332 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code SIGNAL ASSY BLOCK PARTS LIST 9GJANK1562 M Shield Cover 9GJANG2304 M PCB Sub Frame 9GJAEC1611 M Lead Clamper M 9GJAWV1726 M Sub Video Ass’y...
Page 333 64LHP5000 PROJECTOR UNIT SIGNAL ASSY BLOCK...
Page 334 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code AMP BLOCK PARTS LIST 9GJAWV1712 M AMP Ass’y 9GJAEC1418 M Grommet 9GJABA1099 M Screw 9GJABZ30P100FZ M Screw 9GJBBZ30P080FZ M Screw 9GJAEC1783 M Cable Clip D3M...
Page 335 64LHP5000 PROJECTOR UNIT AMP BLOCK...
Page 336 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code DEFLECTION BLOCK PARTS LIST 9GJAWV1731 M Def. Service Ass’y 9GJBBZ30P080FZ M Screw 9GJABZ30P100FZ M Screw 9GJVBZ30P200FM M Screw 9GJAEC1782 M Cable Clip D3S...
Page 337 64LHP5000 PROJECTOR UNIT DEFLECTION BLOCK...
Page 338 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code POWER SUPPLY/AC IN BLOCK PARTS LIST 9GJAWV1710 M Power Supply Ass’y 9GJBBZ30P080FZ M Screw 9GJABZ30P100FZ M Screw 9GJAEC1782 M Cable Clip D3S 9GJANA1582...
Page 339 64LHP5000 PROJECTOR UNIT POWER SUPPLY/AC IN BLOCK Power Supply Block AC IN Block...
Page 340 64LHP5000 PROJECTOR UNIT Mark Ref. No. Part No. Description Code Mark Ref. No. Part No. Description Code PACKING PARTS LIST NOTE : As for accessory parts of part No.22, 27 and 29 to 32, refer to page 320. 9GJAHD2996 M Upper Carton (64WS)
Page 341: Packing Of The Set
64LHP5000 PROJECTOR UNIT PACKING OF THE SET 17,18,24,35 22x12 29-31...
Page 342 Mark Ref. No. Part No. Description Code COPYRIGHT © 1999 BY SHARP CORPORATION ALL RIGHTS RESERVED. No part of this publication may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, without prior written permission of the publisher.

Sharp 64LHP5000 Service Manual

Quick Links

Related Manuals for Sharp 64LHP5000

Summary of Contents for Sharp 64LHP5000

Table of Contents