Table of Contents
Advertisement
Advertisement
Table of Contents
Related Manuals for AEG AGN6500
Summary of Contents for AEG AGN6500
- Page 2 Engine Switch AC Breaker DC Breaker Key Starter Carburetor Drain Screw Fig. 2 Fig. 1 Fuel Tank Fuel Cap Fuel Valve Choke Lever Air Filter Oil Light Fig. 3 Recoil Starter Grip Oil Drainage Bolt Lock Nut Hitch Pin Frame Wheel Flat Screw, 2 in.
- Page 3 16 mm(5/8 in.) 108 mm (4-1/4 in.) Fig. 6 Fig. 7 Oil Cap / Dipstick Oil Cap / Dipstick Oil Fill Hole Oil Fill Hole Fig. 8 Fig. 9 Fuel Tank Extension Cord Fuel Cap Fig. 10 Fig. 11...
- Page 4 Twist-lock Receptacle Extension Cord Twist-lock Plug Recoil Starter Grip Fig. 12 Fig. 13 To Start Choke Lever (Choke closed) Filter Filter To Run (Choke open) Fuel Valve Fuel Valve Fig. 14 Fig. 15 Spark Plug Filter Elements Spark Plug Cap Bolt Air Filter Cover...
-
Page 5: General Safety Rules
Empty fuel tank, close fuel valve, and restrain the unit from INTRODUCTION moving before transporting in a vehicle. Allow engine to cool for five minutes before refueling. This product has many features for making its use more pleasant and enjoyable. Safety, performance, and dependability have To reduce the risk of fire and burn injury, handle fuel with been given top priority in the design of this product, making it care. - Page 6 Do not connect to a building’s electrical system unless a SYMBOLS transfer switch has been properly installed by a qualified electrician. Some of the following symbols may be used on this tool. Please study them and learn their meaning. Proper interpretation of Do not allow the generator’s fuel tank to overflow when these symbols will allow you to operate the tool better and filling.
-
Page 7: Power Management
Total Continuous (Running) Watts 2575 Turn the fuel valve to the on or off Plus Additional Surge Watts +300 position. Equals Total Generator Output Required 2875 (to start all items simultaneously) The guaranteed sound pressure level 77 dB 77 dB 77 dB 77 dB 77 dB... -
Page 8: Specifications
2350 Noise Level (4m) LpA dB (A) Hair Dryer 1250 1250 Noise Level (7m) LpA dB (A) DIY/Job Site Noise Level LwA dB (A) Quartz Halogen Work Light 1000 1000 1200 Reciprocating Saw 1400 Voltage (V) Fault Current Rating (A) 1400 2300 Trip Current Rating (mA) - Page 9 RECEPTACLES See Figure 4. Your generator has the following single phase, 50 Hz outlets: Locate the following items: two 240 Volt AC, 15 Amp receptacle. These can be used for 2 legs with rubber feet operating appropriate appliances, electrical lighting, tools, and 6 flat washers motor loads.
-
Page 10: Operation
REMOVABLE CONTROL PANEL Remember that a careless fraction of a second is sufficient to inflict serious injury. See Figure 6. To detach the removable control panel from the generator: WARNING: Turn off the generator. Do not use any attachments or accessories not Loosen the latch on the removable control panel and pull recommended by the manufacturer of this product. -
Page 11: Removable Control Panel
Start and run the engine for at least 5 minutes to allow The generator can be turned OFF from the removable control stabiliser to treat the entire fuel system. panel or the off switch on the unit. NOTE: You must push the off switch and hold it until the engine has fully stopped. -
Page 12: General Maintenance
it until the engine has fully stopped or turn the key to off Reinstall the oil cap/dipstick. position. NOTE: Used oil should be disposed of at an approved disposal site. See your local oil retailer for more information. Turn the key to “OFF” position (Electric start only). FUEL FILTER To stop the engine in an emergency situation: The fuel filter prevents dirt and water that may have gotten into... -
Page 13: Draining The Carburetor
When the fuel has drained from the tank, close the fuel valve and reinstall fuel line on barb. DRAINING THE CARBURETOR See Figure 2. Turn the engine switch OFF ( O ). Close the fuel valve. Position an approved fuel container under the carburetor drain screw to catch fuel;... -
Page 14: Storage Time
MAINTENANCE STORAGE When preparing the generator for storage, follow the guidelines below. STORAGE TIME PRIOR TO STORING No special preparation is required. Less than 1 month Empty fuel from the fuel tank. 1 to 2 months Empty fuel from the fuel tank. 2 months to 1 year Drain fuel from the carburetor. -
Page 15: Troubleshooting
TROUBLESHOOTING PROBLEM POSSIBLE CAUSE SOLUTION Engine will not start. Engine switch is OFF. Turn engine switch to ON. No fuel. Fill fuel tank. Oil level is low. Fuel valve is OFF. Turn fuel valve ON. Spark plug faulty, fouled, or improperly Replace spark plug. -
Page 16: Wiring Diagram
WIRING DIAGRAM following wiring diagram. Generator Residual Current Device Outlet Frame... - Page 17 WIRING DIAGRAM...